HOW TO MAKE NITROGLYCERIN Almost all modern explosives are a derivative of a nitric acid base. Although fuming nitric acid (98 percent solution in water) is not an explosive in itself, it is explosive when mixed with many other compounds. This process of mixing a compound with nitric acid chemically is called the nitrating principle. The best-known nitrating agent is glycerin, but many others can be and are used. Mercury, sugar, cork, wheat germ, sawdust, starch, lard, and indigo are all common nitrating agents and are used in modern industry. For example when sawdustis nitrated, it becomes nitrocellulose, and is used in smokeless powder. Mercury fulminate (nitrated mercury) is a very powerful and effective detonator. Nitroglycerin is a high explosive, with an incredibly unstable nature. It can explode for the most minute reasons, such as a change of one or two degrees in temperature, or a minor shock. Because of nitroglycerin's unstable nature, I would suggest that only people with an extensive background training in both chemistry and explosives try this procedure. Nitroglycerin 1. Fill a 75-milliliter beaker, to the 13-ml. level, with fuming red nitric acid, of 98 percent concentration. 2. Place beaker in an ice bath and allow to cool below room temperature. 3. After it is cooled, add to it three times the amount of fuming sulfuric acid (99 percent). In other words, add to the now-cool fuming nitric acid 39 milliliters of fuming sulfuric acid. When mixing any acids, always do it slowing and carefully to avoid splattering. 4. When the two are mixed, lower their temperature, by adding more ice to the bath, to about 10 or 15 degrees Centegrade. This can be measured by using a mercury-operated Centegrade thermometer. 5. When the acid solution has cooled to the desired temperature, it is ready for the glycerin. The glyverin MUST BE ADDED IN SMALL AMOUNTS USING A MEDICINE DROPPER. Glycerin is added, slowly and carefully, until the entire surface of the acid is covered with it. 6. This is a dangerous point, since the nitration will take place as soon as the glycerin is added. The nitration will produce heat, so the solution MUST BE KEPT BELOW 30 DEGREES C. If the solution should go above 30 degrees, the beaker should be taken out of the ice bath and the solution should be carefully poured directly into the ice bath, since this will prevent an explosion. 7. For about the first ten minutes of the nitration, the mixture should be gently stirred. In a normal reaction, the nitroglycerin will form as a layer ontop of the acid solution, while the sulfuric acid will absorb the excess water. 8. After the nitration has taken place and the nitroglycerin has formed at the top of the acid solution, the entire beaker should be transferred very slowly and carefully to another beaker of water. When this is done, the nitroglycerin will settle to the bottom, so that most of the acid solution can be drained away. 9. After removing as much acid as possible without disturbing the nitro- glycerin, remove the nitroglycerin with an eyedropper and place it in a bicarbonate of soda (sodium bicarbonate) solution. The sodium bicarbonate is an alkali and will neutralize much of the acid remaining. This process should be repeated as many times as necessary using blue litmus paper to check for the presence of acid. The remaining acid only make the nitroglycerin more unstable than is normally is. 10. The final step is to remove the nitroglycerin from the bicarbonate. This is done with an eyedropper, slowly and carefully. The usual test to see if nitration has been successful is to place one drop of the nitroglycerin on a metal plate and ignite it. If it is true nitro- glycerin, it will burn with a clear bule flame. CAUTION: Nitroglycerin is EXTREMELY sensitive to decomposition, heating, dropping, or jarring, and may explode even if left undisturbed and cool. KNOW WHAT YOU ARE DOING BEFORE YOU DO IT!!!!! -------------------------------------------------------------------------------- This section has been reprinted without permision from the author or publisher of "The Anarchist Cookbook" by William Powell.